- Wattage (Gas): 4,000 W / 3,500 W
- THD: < 20%
- Noise Level: 68 dBA
- Fuel Type: Gasoline
- RV Ready: Yes
- Run Time@ 25% load: Unspecified
- Run Time@ 50% load: 12 h
- Weight: 99.2 lbs
Table Of Contents
We are proud of our independence and have no ties to manufacturers. To maintain our objectivity, we do not accept free products. Our income is generated by advertising fees paid by retailers for qualifying purchases.
Description
The Champion 46596 has a Champion OHV 4-stroke engine that is 196 cc. It has a 120V output, runs on gas, and has a running wattage of 3,500W and a peak wattage of 4,000W. The noise level of the generator is 68 dBA, which is less than an office. It has a traditional pull-start mechanism. With a full tank, the 46596 can run for about 12 hours at 0.5 load and 3.8 gallons of fuel (fuel consumption is approximately 0.32 GPH). Since the 46596 has a THD of about 20%, it is best not to use it to power electronics that are sensitive to noise.
Outlets
The control panel has three AC outlets: one for 120V 20A (5-20R), one for 120V 30A (L5-30R), and one for 120V 30A (TT-30R).
This Champion generator is ready for an RV because it has a TT-30R plug (TT stands for “Travel Trailer”).Features
The 46596 and its control panel have an Intelligauge meter that shows voltage, frequency, and the number of hours the battery has been used.
This makes it easier to keep track of its status and activity.In terms of safety, the generator can be used without worry because it has an automatic shut-off for low oil and an overload protection (circuit breaker).Volt GuardTM, which is built into Champion, protects your equipment and appliances from voltage spikes.The Champion 46596 comes with the usual paperwork and an owner’s manual , so you can start using it right away.It also comes with a funnel and a tool kit.Mobility
The Champion 46596 is 23.2 inches long, 17.5 inches wide, and 19.6 inches high.
It has a typical open frame design that makes it stable and allows it to be raised above ground level.This type of design is great for tough environments and heavy outdoor use.The 46596 is 99.2 pounds, which means you can take it anywhere.Also, the generator’s open frame makes it easier to hold and move from one place to another.Product Videos
The following charts show how some of the most important features of the Champion-46596 compare to other generators with the same power output.
**Fuel efficiency is give in relative percentage, 0 being the lowest and 1 being the highest value. Please see below specification table for actual value.
Specifications
Generic
| Inverter | No |
| Fuel efficiency | 0.186 gal/kWh |
| Parallel capable | No |
| RV ready | Yes |
| Fuel | Gasoline |
| Engine | 196 cc Champion OHV 4-stroke |
| Starting system | Recoil |
| Voltage | AC: 120V 60 Hz |
Power
| Gasoline | Propane | |
| Running watts | 3,500 W | n/a |
| Starting watts | 4,000 W | n/a |
| Running amps (@120/240V) | 29.2 amps | n/a |
| Peak amps (@120/240V) | 33.3 amps | n/a |
| Run time @50% load | 12 h | n/a |
| Run time @25% load | Unspecified | n/a |
Control Panel
| GFCI outlets | No |
| Covered outlets | No |
| Automatic Voltage Regulator | Yes |
| AC outlets | 1x 120V 20A (5-20R); 1x 120V 30A (L5-30R); 1x 120V 30A (TT-30R) |
| DC outlets | No |
| Data center | VFT |
| Indicators | No |
| Fuel tank | Steel, 3.8 gal |
| Fuel gauge | No |
Mixed
| Weight | 99.2 lbs |
| Approx. dimen. (L x W x H) | 23.2 x 17.5 x 19.6 in |
| Noise (lower limit) | 68 dBA |
| THD | < 20% |
| Compliance | EPA |
| Security | Low oil, overload and Volt Guard™ surge protection |
| Spark arrestor | Yes |
| Accessories included | Funnel and tool kit |
| Warranty | 3 years |
- We compared more than 500 portable generators at 50% load. We found that there is “skewed right” distribution for the difference between 50% load and 25% load and the median comes at 1.43. With this number we converter all the 25% load runtime to 50% load. Same with the propane efficiency, where median is 1.38.
- For some generators where propane runtime was not given, we used NIST 1994 GGE (Gasoline Gallon Equivalent) formula: 5.66 lbs. of propane = 1 gal of gasoline. All propane runtime is for 20 lbs. propane tank (4.7 gallons).
- Unlike many other sites, we actually tried to find out information about each of the above requirements. However, we are human and are therefore capable of the odd oversight or mistake. Please let us know if you spot any missing or erroneous values so that we can fix them.
About the Manufacturer
A US-based producer of power equipment, Champion Power Equipment was established in 2003.
The comparatively tiny business has established a name for itself in the portable generator market as well as the larger power equipment market, with a concentration on heavy duty machinery like log cutters, snow blowers, chipper shredders, etc.Their whole product line is American-engineered.The corporation does not, however, disclose the country of origin of its parts.Warranty Information
There is a warranty on the Champion 46596 for up to 3 years.
This warranty may not cover all parts of the generator or may only cover certain parts.Champion’s warranty policies can tell you more about how long the warranty on a Champion generator lasts.You can also call their customer service line at 1-877-338-0999.